自吸泵進口管道漏氣可以吸的上液?jiǎn)幔?/title>
<div align="center"><span style="font-size:14px">作者：自吸泵 來源：自吸泵 發布時間：2020-01-13</span></div>
<span style="font-size:16px;"> 自吸泵是可以自吸和防空運轉的泵，自吸泵泵腔具有儲液功能，使用前泵腔灌滿液體，后期可直接啟動運轉，液體在抽空的狀況下，泵具有儲液腔，不會造成泵空轉而損壞泵腔部件，自吸泵在低液位工況下非常適用，自吸泵根據采用有鑄鐵自吸泵，不銹鋼自吸泵，氟塑料自吸泵；材質不同，適用介質也不同，對于強酸強堿強腐蝕液體，氟塑料自吸泵較適用。用戶在使用自吸泵過程中，出現吸不上液是什么原因呢，進口管道漏氣會有影響嗎？<br /> 自吸泵是依靠葉輪的高速旋轉使自吸泵內產生低壓區而進行吸水的，所以自吸泵必須保證其進水管不漏，即保證外界空氣不能進入進水管。否則，不僅會影響水泵效率，而且水泵作業時產生嚴重的振動和噪音。氟塑料自吸泵啟動前，只需首次使用時灌滿泵腔，后期使用無需灌液，可直接啟動，完成輸送，氟塑料自吸泵在自吸時，進口管道出現漏氣是沒法完成自吸的；<br /> <img alt="自吸泵" src="http://www.6c3c.com/d/file/telongzixun/2020-01-13/c5bf9acfde8daa05c5d59a1142bef155.jpg" style="width: 500px; height: 667px;" /><br />一、自吸泵在安裝前的要求有哪些呢？<br /> 1、自吸泵在安裝前一定要確認好進口管道的長度和高度不能超過自吸泵的允許吸程范圍，進口管道一定不能有漏氣的現象，應該保證是全密封的管道，就算有針眼大的小孔也將會影響自吸泵的自吸能力。 <br />2、自吸泵安裝時盡量不要固定在用槽鋼焊接的支架上，因?yàn)椴垆撆c泵接觸的面太少，在緊固底座螺絲的同時由于泵底座有很大一部分是懸空的所以容易把底座及聯軸器同心度給破壞，所以裝在槽鋼支架上的自吸泵是容易出現振動大聯軸器很容易損壞的現象。<br />3、自吸泵在安裝時不能圖便宜，有的用戶在新購買的自吸泵拿去使用時直接把出廠固定自吸泵的木條底座和自吸泵一起放在地面上投入使用，這種作法是不可取的，這樣很容易導致自吸泵發生振動及噪音而使自吸泵發生機械故障。正確的方法是把泵底座固定在實心平整的平臺或者堅硬的地面上。<br /> <img alt="自吸泵" src="http://www.6c3c.com/d/file/telongzixun/2020-01-13/a258eea8693a319506c1e1639b66c05f.jpg" style="width: 500px; height: 667px;" /><br />二、自吸泵停止，啟動注意事項及操作順序：<br />1、使泵停止轉動，首先必須關閉吐出管路上的閘閥，在寒冷季節，應將泵體內的儲液和軸承體冷卻室內的水放空，以防凍裂機泵部件。<br />2、啟動自吸泵時：注意泵軸的轉向是否正確。注意轉動時有無不正常的聲響和振動。注意壓力表及真空表讀數，起動后當壓力表及真空表的讀數經過一段時間的波動而指示穩定后，說明自吸泵內已經上液，進入正常輸液作業。<br /> <img alt="自吸泵" src="http://www.6c3c.com/d/file/telongzixun/2020-01-13/f0195cb7c6fdf67e79f0cc4875549e29.jpg" style="width: 500px; height: 1000px;" /><br />三、自吸泵在工作過程中如發生強烈振動和噪聲，有可能是泵發生汽蝕所致，汽蝕產生的原因有兩種：一是進口管流速過大，二是吸程過高。流速過大時可調節出口控制閥，升高壓力表讀數，在進口管路有堵塞時則應 及時排除;吸程太高時可適當降低泵的安裝高度。在自吸泵進入正常輸液作業前即自吸過程中，應特別注意泵內水溫升高情況，如果這個過程過長，泵內水溫過高，則停泵檢查其原因。如果自吸泵內液體溫度過高而引起自吸困難，那么可以暫時停機，利用吐出管路中的液體倒流回泵內或向泵體上加儲液口處直接向泵內補充液體，使泵內液體降溫，然后起動即可。<br /> 自吸泵在工作過程中因故停泵，需再起動時，出口控制閥應稍開(不要全閉)，這樣既有利于自吸過程中氣體從吐出口排出，又能保證尖在較輕的負責下啟動。注意檢查管路系統有無滲漏現象。</span><br /> </div>
</div>
</div>
<div id="xrf5htrj" class="chanpin-right">
<h1>資訊新聞中心</h1>
<ul>
<li><a href="/bengfaxinwen/" alt="">新聞資訊</a></li>
<dd><a href="/telongzixun/" alt="">皖金資訊</a></dd>
<dd><a href="/bengfaxinwen/" alt="">行業新聞</a></dd>
<dd><a href="/bengfawenda/" alt="">泵閥百科</a></dd>
<li><a href="/jinpaikehu/" alt="">客戶中心</a></li>
<dd><a href="/jinpaikehu/" alt="">金牌客戶</a></dd>
<li><a href="/ziliaoxiazai/" alt="">資料下載</a></li>
<dd><a href="/zizhizhengshu/" alt="">資質證書</a></dd>
<dd><a href="/chanpinyangben/" alt="">產品樣本</a></dd>
</ul>
<div id="xrf5htrj" class="cont-right">
<img src="/images/kefu.jpg">
<p>安徽皖金泵閥制造有限公司</p>
<p>聯系電話：0563-5511202</p>
<p>網址：www.6c3c.com</p>
</div>
</div>
</div>
</div>
<div id="xrf5htrj" class="footer">
<ul class="footer-top">
<li><a href="/" title="皖金泵閥">公司首頁</a></li>
<li><a href="/cilibeng.html" title="磁力泵">磁力泵</a></li>
<li><a href="/lixinbeng.html" title="離心泵">離心泵</a></li>
<li><a href="/zixibeng.html" title="自吸泵">自吸泵</a></li>
<li><a href="/cilibeng/" title="泵閥產品">泵閥產品</a></li>
<li><a href="/chenggonganli/" title="成功案例">成功案例</a></li>
<li><a href="/lianxiwomen/2016-07-04/173.html" title="關于皖金泵閥">關于皖金</a></li>
<li><a href="/bengfaxinwen/" title="泵閥資訊">泵閥資訊</a></li>
<li><a href="/lianxiwomen/2016-06-13/88.html" title="聯系我們">聯系我們</a></li>
</ul>
<div id="xrf5htrj" class="footer-down">
<ul class="footer-down-p">
<li>公司地址：安徽省涇縣經濟開發區</li>
<li>公司電話：0563-5511202</li>
<li>公司傳真：0563-5511006</li>
<li>手機聯系：18134562366</li>
<li>公司郵箱：bengfacn@163.com</li>
<li>公司網址：http://www.6c3c.com/</li>
<li>客服 QQ：2325216967</li>
<li><a title="皖I(lǐng)CP備16024680號-1">皖I(lǐng)CP備16024680號-1</a></li>
</ul>
<div id="xrf5htrj" class="footer-down-logo">
<a href="/index.html" title="皖金泵閥"><img src="/images/dibulogo.png" alt="皖金泵閥"></a>
</div>
<ul class="footer-down-p2">
<li><a href="/cilibeng/2016-05-28/6.html">JCQ不銹鋼磁力泵</a></li>
<li><a href="/cilibeng/2020-08-12/1766.html">WJC不銹鋼磁力泵</a></li>
<li><a href="/cilibeng/2020-08-12/1765.html">WJC-F氟塑料磁力泵</a></li>
<li><a href="/cilibeng/2019-09-10/1565.html">WJCG-F襯氟磁力管道泵</a></li>
<li><a href="/cilibeng/2018-01-09/997.html">WJCG不銹鋼磁力管道泵</a></li>
<li><a href="/cilibeng/2017-07-04/715.html">ZCQ不銹鋼磁力自吸泵</a></li>
</ul>
<ul class="footer-down-p2">
<li><a href="/lixinbeng/2021-04-07/1918.html">WJLB臥式管道離心泵</a></li>
<li><a href="/lixinbeng/2021-04-07/1917.html">WJLG立式管道離心泵</a></li>
<li><a href="/lixinbeng/2020-02-26/1669.html">WJL-F耐腐蝕襯氟離心泵</a></li>
<li><a href="/lixinbeng/2019-11-16/1609.html">ISG立式管道離心泵</a></li>
<li><a href="/lixinbeng/2016-05-28/9.html">IHF-J氟塑料離心泵</a></li>
<li><a href="/lixinbeng/2016-05-28/10.html">FSB-L氟塑料（合金）離心泵</a></li>
</ul>
<div id="xrf5htrj" class="footer-down-weixin">
<img src="/layout/images/foot_03.jpg" alt="耐腐蝕離心泵">
</div>
</div>
</div>
<footer>
<div class="friendship-link">
<p>感谢您访问我们的网站，您可能还对以下资源感兴趣：</p>
<a href="http://www.6c3c.com/" title="两棒进一洞视频">两棒进一洞视频</a>
<div class="friend-links">
</div>
</div>
</footer>
<a href="http://" target="_blank">镇沅</a>|
<a href="http://" target="_blank">绩溪县</a>|
<a href="http://" target="_blank">塔河县</a>|
<a href="http://" target="_blank">布尔津县</a>|
<a href="http://" target="_blank">民和</a>|
<a href="http://" target="_blank">通江县</a>|
<a href="http://" target="_blank">彭阳县</a>|
<a href="http://" target="_blank">柞水县</a>|
<a href="http://" target="_blank">天全县</a>|
<a href="http://" target="_blank">抚顺县</a>|
<a href="http://" target="_blank">视频</a>|
<a href="http://" target="_blank">灌南县</a>|
<a href="http://" target="_blank">万山特区</a>|
<a href="http://" target="_blank">金寨县</a>|
<a href="http://" target="_blank">京山县</a>|
<a href="http://" target="_blank">九寨沟县</a>|
<a href="http://" target="_blank">贵南县</a>|
<a href="http://" target="_blank">伊春市</a>|
<a href="http://" target="_blank">怀远县</a>|
<a href="http://" target="_blank">宜良县</a>|
<a href="http://" target="_blank">米易县</a>|
<a href="http://" target="_blank">石嘴山市</a>|
<a href="http://" target="_blank">昂仁县</a>|
<a href="http://" target="_blank">句容市</a>|
<a href="http://" target="_blank">咸丰县</a>|
<a href="http://" target="_blank">远安县</a>|
<a href="http://" target="_blank">湄潭县</a>|
<a href="http://" target="_blank">江达县</a>|
<a href="http://" target="_blank">灵台县</a>|
<a href="http://" target="_blank">托克逊县</a>|
<a href="http://" target="_blank">芒康县</a>|
<a href="http://" target="_blank">怀集县</a>|
<a href="http://" target="_blank">余江县</a>|
<a href="http://" target="_blank">临城县</a>|
<a href="http://" target="_blank">甘谷县</a>|
<a href="http://" target="_blank">郑州市</a>|
<a href="http://" target="_blank">白沙</a>|
<a href="http://" target="_blank">罗山县</a>|
<a href="http://" target="_blank">元朗区</a>|
<a href="http://" target="_blank">德州市</a>|
<a href="http://" target="_blank">沙湾县</a>|
<script>
(function(){
var bp = document.createElement('script');
var curProtocol = window.location.protocol.split(':')[0];
if (curProtocol === 'https') {
bp.src = 'https://zz.bdstatic.com/linksubmit/push.js';
}
else {
bp.src = 'http://push.zhanzhang.baidu.com/push.js';
}
var s = document.getElementsByTagName("script")[0];
s.parentNode.insertBefore(bp, s);
})();
</script>
</body><div id="htp77" class="pl_css_ganrao" style="display: none;"><video id="htp77"><em id="htp77"><big id="htp77"><dl id="htp77"></dl></big></em></video><b id="htp77"><meter id="htp77"></meter></b><menuitem id="htp77"><form id="htp77"><legend id="htp77"><label id="htp77"></label></legend></form></menuitem><track id="htp77"></track><address id="htp77"><strike id="htp77"><strong id="htp77"><form id="htp77"></form></strong></strike></address><mark id="htp77"><form id="htp77"></form></mark><strong id="htp77"><optgroup id="htp77"><track id="htp77"><sub id="htp77"></sub></track></optgroup></strong><div id="htp77"></div><ins id="htp77"></ins><dfn id="htp77"></dfn><address id="htp77"><div id="htp77"><strong id="htp77"><form id="htp77"></form></strong></div></address><div id="htp77"><ol id="htp77"></ol></div><dl id="htp77"><legend id="htp77"><listing id="htp77"><u id="htp77"></u></listing></legend></dl><track id="htp77"></track><font id="htp77"><progress id="htp77"></progress></font><pre id="htp77"></pre><th id="htp77"><b id="htp77"></b></th><ins id="htp77"></ins><listing id="htp77"><dfn id="htp77"><mark id="htp77"><form id="htp77"></form></mark></dfn></listing><label id="htp77"><u id="htp77"></u></label><thead id="htp77"><legend id="htp77"><dfn id="htp77"><u id="htp77"></u></dfn></legend></thead><sup id="htp77"><strong id="htp77"></strong></sup><strike id="htp77"></strike><em id="htp77"><big id="htp77"></big></em><pre id="htp77"><p id="htp77"></p></pre><mark id="htp77"></mark><font id="htp77"><progress id="htp77"></progress></font><thead id="htp77"></thead><video id="htp77"><em id="htp77"><div id="htp77"><ol id="htp77"></ol></div></em></video><th id="htp77"><b id="htp77"></b></th><dfn id="htp77"><u id="htp77"><ruby id="htp77"><form id="htp77"></form></ruby></u></dfn><form id="htp77"></form><sup id="htp77"><strong id="htp77"></strong></sup><b id="htp77"><meter id="htp77"><pre id="htp77"><p id="htp77"></p></pre></meter></b><label id="htp77"><th id="htp77"><b id="htp77"><meter id="htp77"></meter></b></th></label><style id="htp77"><nobr id="htp77"></nobr></style><mark id="htp77"><form id="htp77"></form></mark><progress id="htp77"><acronym id="htp77"></acronym></progress><small id="htp77"><ins id="htp77"><address id="htp77"><div id="htp77"></div></address></ins></small><mark id="htp77"><form id="htp77"></form></mark><nobr id="htp77"><small id="htp77"><ins id="htp77"><address id="htp77"></address></ins></small></nobr><p id="htp77"><var id="htp77"><form id="htp77"><output id="htp77"></output></form></var></p><strong id="htp77"></strong><legend id="htp77"><listing id="htp77"><tt id="htp77"><mark id="htp77"></mark></tt></listing></legend><listing id="htp77"></listing><font id="htp77"></font><acronym id="htp77"><style id="htp77"><nobr id="htp77"><small id="htp77"></small></nobr></style></acronym><output id="htp77"><address id="htp77"></address></output><video id="htp77"><sub id="htp77"><div id="htp77"><strong id="htp77"></strong></div></sub></video><progress id="htp77"><acronym id="htp77"><style id="htp77"><nobr id="htp77"></nobr></style></acronym></progress><thead id="htp77"></thead><menuitem id="htp77"></menuitem><ruby id="htp77"><font id="htp77"><legend id="htp77"><acronym id="htp77"></acronym></legend></font></ruby><acronym id="htp77"></acronym><dfn id="htp77"></dfn><legend id="htp77"><dfn id="htp77"><dfn id="htp77"><menuitem id="htp77"></menuitem></dfn></dfn></legend><font id="htp77"></font><legend id="htp77"><label id="htp77"></label></legend><ins id="htp77"><address id="htp77"></address></ins><strike id="htp77"><strong id="htp77"><form id="htp77"><video id="htp77"></video></form></strong></strike><style id="htp77"><th id="htp77"></th></style><track id="htp77"></track><thead id="htp77"><thead id="htp77"><dfn id="htp77"><u id="htp77"></u></dfn></thead></thead><u id="htp77"><ruby id="htp77"><thead id="htp77"><legend id="htp77"></legend></thead></ruby></u><b id="htp77"><ins id="htp77"><pre id="htp77"><p id="htp77"></p></pre></ins></b><strong id="htp77"><optgroup id="htp77"></optgroup></strong><var id="htp77"><form id="htp77"><output id="htp77"><address id="htp77"></address></output></form></var><span id="htp77"><legend id="htp77"></legend></span><div id="htp77"></div><thead id="htp77"></thead><font id="htp77"><progress id="htp77"></progress></font><thead id="htp77"></thead><dl id="htp77"></dl><acronym id="htp77"><p id="htp77"><nobr id="htp77"><form id="htp77"></form></nobr></p></acronym><pre id="htp77"><p id="htp77"></p></pre><span id="htp77"><legend id="htp77"></legend></span><pre id="htp77"></pre><form id="htp77"><ins id="htp77"></ins></form><ol id="htp77"><form id="htp77"><output id="htp77"><em id="htp77"></em></output></form></ol><span id="htp77"><i id="htp77"></i></span><dl id="htp77"></dl><mark id="htp77"></mark><font id="htp77"><progress id="htp77"></progress></font><pre id="htp77"><style id="htp77"></style></pre><strike id="htp77"><strong id="htp77"><form id="htp77"><output id="htp77"></output></form></strong></strike><meter id="htp77"><acronym id="htp77"></acronym></meter><sub id="htp77"><div id="htp77"></div></sub><strike id="htp77"><var id="htp77"><optgroup id="htp77"><output id="htp77"></output></optgroup></var></strike><ol id="htp77"><optgroup id="htp77"></optgroup></ol><strong id="htp77"><optgroup id="htp77"></optgroup></strong><meter id="htp77"><pre id="htp77"><style id="htp77"><nobr id="htp77"></nobr></style></pre></meter><rp id="htp77"><thead id="htp77"></thead></rp><mark id="htp77"></mark><ins id="htp77"></ins><output id="htp77"><sub id="htp77"></sub></output><legend id="htp77"><sup id="htp77"></sup></legend><var id="htp77"><small id="htp77"><ins id="htp77"><address id="htp77"></address></ins></small></var><rp id="htp77"><b id="htp77"><progress id="htp77"><acronym id="htp77"></acronym></progress></b></rp><form id="htp77"></form><th id="htp77"><font id="htp77"></font></th><ol id="htp77"><pre id="htp77"><track id="htp77"><tt id="htp77"></tt></track></pre></ol><tt id="htp77"><big id="htp77"></big></tt><legend id="htp77"></legend><font id="htp77"><progress id="htp77"></progress></font><em id="htp77"><div id="htp77"></div></em><listing id="htp77"><dfn id="htp77"></dfn></listing><legend id="htp77"><dfn id="htp77"></dfn></legend><menuitem id="htp77"><form id="htp77"><thead id="htp77"><dfn id="htp77"></dfn></thead></form></menuitem><strike id="htp77"><strong id="htp77"><optgroup id="htp77"><output id="htp77"></output></optgroup></strong></strike><i id="htp77"><listing id="htp77"></listing></i><listing id="htp77"></listing><label id="htp77"></label><optgroup id="htp77"><output id="htp77"></output></optgroup><menuitem id="htp77"><span id="htp77"><legend id="htp77"><listing id="htp77"></listing></legend></span></menuitem><em id="htp77"></em><acronym id="htp77"></acronym><small id="htp77"><ins id="htp77"><address id="htp77"><strike id="htp77"></strike></address></ins></small><rp id="htp77"><b id="htp77"><progress id="htp77"><pre id="htp77"></pre></progress></b></rp><dl id="htp77"></dl><dl id="htp77"><i id="htp77"><listing id="htp77"><u id="htp77"></u></listing></i></dl><ruby id="htp77"><thead id="htp77"></thead></ruby><font id="htp77"><progress id="htp77"></progress></font><thead id="htp77"></thead><dfn id="htp77"><ruby id="htp77"><form id="htp77"><legend id="htp77"></legend></form></ruby></dfn><legend id="htp77"><label id="htp77"></label></legend><sup id="htp77"><strong id="htp77"><rp id="htp77"><font id="htp77"></font></rp></strong></sup><progress id="htp77"><acronym id="htp77"><style id="htp77"><nobr id="htp77"></nobr></style></acronym></progress><b id="htp77"><meter id="htp77"><acronym id="htp77"><p id="htp77"></p></acronym></meter></b><strong id="htp77"><optgroup id="htp77"><video id="htp77"><address id="htp77"></address></video></optgroup></strong><listing id="htp77"><dfn id="htp77"></dfn></listing><video id="htp77"></video><em id="htp77"><big id="htp77"></big></em><optgroup id="htp77"></optgroup><big id="htp77"></big><pre id="htp77"></pre><style id="htp77"><th id="htp77"></th></style><address id="htp77"><strike id="htp77"><var id="htp77"><form id="htp77"></form></var></strike></address><strong id="htp77"><optgroup id="htp77"></optgroup></strong><label id="htp77"><strong id="htp77"></strong></label><font id="htp77"><progress id="htp77"></progress></font><big id="htp77"></big><th id="htp77"></th><output id="htp77"><sub id="htp77"><div id="htp77"><dl id="htp77"></dl></div></sub></output><strike id="htp77"></strike><legend id="htp77"><dfn id="htp77"><dfn id="htp77"><ruby id="htp77"></ruby></dfn></dfn></legend><i id="htp77"><listing id="htp77"></listing></i><legend id="htp77"><listing id="htp77"><dfn id="htp77"><menuitem id="htp77"></menuitem></dfn></listing></legend><div id="htp77"></div><strong id="htp77"></strong><label id="htp77"><nobr id="htp77"><small id="htp77"><meter id="htp77"></meter></small></nobr></label></div>
</html>
